Drying-induced restructured jerky analog developed using a combination of edible insect protein and textured vegetable protein

With a growing world population and increasingly demanding consumers, the production of sufficient protein from livestock, poultry, and fish represents a serious challenge for the future. Approximately 1,900 insect species are eaten worldwide, mainly in developing countries. They constitute quality food and feed, have high feed conversion ratios, and emit low levels of greenhouse gases. Some insect species can be grown on organic side streams, reducing environmental contamination and transforming waste into high-protein feed that can replace increasingly more expensive compound feed ingredients, such as fish meal. This requires the development of cost-effective, automated mass-rearing facilities that provide a reliable, stable, and safe product. In the tropics, sustainable harvesting needs to be assured and rearing practices promoted, and in general, the food resource needs to be revalorized. In the Western world, consumer acceptability will relate to pricing, perceived environmental benefits, and the development of tasty insect-derived protein products.

The influence of environmental factors (product composition and storage conditions) on the selection, growth rate and metabolic activity of the bacterial flora is presented for meat (pork and beef) and cooked, cured meat products. The predominant bacteria associated with spoilage of refrigerated beef and pork, are Brochothrix thermosphacta, Carnobacterium spp., Enterobacteriaceae, Lactobacillus spp., Leuconostoc spp., Pseudomonas spp. and Shewanella putrefaciens. The main defects in meat are off-odours and off-flavours, but discolouration and gas production also occur. Bacteria associated with the spoilage of refrigerated meat products, causing defects such as sour off-flavours, discolouration, gas production, slime production and decrease in pH, consist of B. thermosphacta, Carnobacterium spp. Luctobacillus spp. Leuconostoc spp. and Weissella spp. Analysis of spoilage as measured by bacterial and chemical indicators is discussed. It is concluded that a multivariate approach based on spectra of chemical compounds, may be helpful in order to analyse spoilage, at least for spoilage caused by lactic acid bacteria. The consequences of bacteria bacteria interactions should be evaluated more.

Tenebrio molitor, Zophobas morio, Alphitobius diaperinus, Acheta domesticus and Blaptica dubia were evaluated for their potential as a future protein source. Crude protein content ranged from 19% to 22% (Dumas analysis). Essential amino acid levels in all insect species were comparable with soybean proteins, but lower than for casein. After aqueous extraction, next to a fat fraction, a supernatant, pellet, and residue were obtained, containing 17-23%, 33-39%, 31-47% of total protein, respectively. At 3% (w/v), supernatant fractions did not form stable foams and gels at pH 3, 5, 7, and 10, except for gelation for A. domesticus at pH 7. At 30% w/v, gels at pH 7 and pH 10 were formed, but not at pH 3 and pH 5. In conclusion, the insect species studied have potential to be used in foods due to: (1) absolute protein levels; (2) protein quality; (3) ability to form gels.